IllustrationTHE CAR TURNS OFF WHILE DRIVING SIMILAR TO PROBLEM I HAD WITH MY 1999 HONDA CRV INGITION SWITCH BEEN DOING IT FOR SEVERAL DAYS TODAY SMOKE CAME OUT FROM THE STEERING COLUM
2002 Acura Mdx
Owner reports · Recalls · Investigations
More warning signs than most Mdx years
Owner complaints for the 2002 Acura Mdx are substantially higher than the model-year median of 101.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Mdx years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
100–25K
1125–50K
2150–75K
4375–100K
45100–150K
31150K+
161 reports with mileage · 43 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 124 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports2 fire reports4 injury reports
Electrical System complaints
12 reportsSRS DEVICE FAILED, LEAVING AIR BAGS INOPERABLE. DEALER ASKED FACTORY REP TO AUTHORIZE SERVICE. DENIED BY ACURA. THIS IS A SAFETY HAZARD. RESEARCH INDICATES IDENTICAL PROBLEMS IN OTHER VEHICLES, A PRIOR CLASS ACTION SETTLEMENT AND OTHER COMPLAINTS. SRS WARNING LIGHT STAYS ON. BOTH DEALER AND INDEPENDENT GARAGE TESTED AND CO…
Read full complaint
SRS DEVICE FAILED, LEAVING AIR BAGS INOPERABLE. DEALER ASKED FACTORY REP TO AUTHORIZE SERVICE. DENIED BY ACURA. THIS IS A SAFETY HAZARD. RESEARCH INDICATES IDENTICAL PROBLEMS IN OTHER VEHICLES, A PRIOR CLASS ACTION SETTLEMENT AND OTHER COMPLAINTS. SRS WARNING LIGHT STAYS ON. BOTH DEALER AND INDEPENDENT GARAGE TESTED AND CONFIRMED UNIT IS DEFECTIVE.
RECALL ON APRIL 1ST MY MOTHER DROVE HER RECENTLY PURCHASED 2002 ACCURA MDX TO WORK ABOUT A 5 MIN DRIVE TEN MIN AFTER SHE PARKED AND ARRIVED TO WORK HER CAR WAS INFLAMS AND FIRE FIGHTER INVESTIGATORS STATED IT WAS A ELECTRICAL FIRE THAT CAUSED HER CAR TO BLOW UP
TL* THE CONTACT OWNS A 2002 ACURA MDX. THE CONTACT STATED THAT THE KEY RANDOMLY WOULD NOT TURN OVER. INTERMITTENTLY, THE ANTI-THEFT FEATURE ACTIVATED AND PREVENTED THE VEHICLE FROM STARTING. THE FAILURE OCCURRED MORE THAN FIVE TIMES IN WHICH THERE WAS A SUDDEN LOSS OF POWER AND THE VEHICLE STALLED. THE CONTACT HAD TO MAKE NUMERO…
Read full complaint
TL* THE CONTACT OWNS A 2002 ACURA MDX. THE CONTACT STATED THAT THE KEY RANDOMLY WOULD NOT TURN OVER. INTERMITTENTLY, THE ANTI-THEFT FEATURE ACTIVATED AND PREVENTED THE VEHICLE FROM STARTING. THE FAILURE OCCURRED MORE THAN FIVE TIMES IN WHICH THERE WAS A SUDDEN LOSS OF POWER AND THE VEHICLE STALLED. THE CONTACT HAD TO MAKE NUMEROUS ATTEMPTS TO MANEUVER THE KEY TO GET THE VEHICLE TO RESTART. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 215,000. UPDATED 04/14/16*LJ *TR
THE KEYS CAN BE REMOVED WHILE CAR IS NOT IN PARK SO IT ROLLED AND BUMPED INTO ANOTHER CAR. I CHECKED THE RECALL AND IT IS NOT INCLUDED IN THEIR RECALL. MY CAR IS 2002 ACURA MDX AND THE YEAR THEY HAVE RECALL IS 2003 VERSION.
TL* THE CONTACT OWNS A 2002 ACURA MDX. THE CONTACT STATED THAT WHILE THE VEHICLE WAS UNOCCUPIED AND PARKED, IT ROLLED AWAY AND THEN CRASHED INTO TWO OTHER PARKED VEHICLES. A POLICE REPORT WAS FILED. THERE WERE NO PERSONAL INJURIES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO STATED THAT THE IGNITION SWITCH CYLINDER WOULD …
Read full complaint
TL* THE CONTACT OWNS A 2002 ACURA MDX. THE CONTACT STATED THAT WHILE THE VEHICLE WAS UNOCCUPIED AND PARKED, IT ROLLED AWAY AND THEN CRASHED INTO TWO OTHER PARKED VEHICLES. A POLICE REPORT WAS FILED. THERE WERE NO PERSONAL INJURIES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO STATED THAT THE IGNITION SWITCH CYLINDER WOULD NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
CAR LOCKED ITSELF WITH DRIVER AND PASSENGERS INSIDE CAR. NO ONE COULD OPEN DOORS FROM INSIDE. THE MANUAL UNLOCK WOULD NOT UNLOCK DOORS. DRIVER WAS ABLE TO UNLOCK HIS DOOR BY OPENING WINDOW AND USING THE OUTSIDE DOOR HANDLES. *TR THIS INCIDENT HAS HAPPENED THREE TIMES. ON ANOTHER INCIDENT WHILE PARKING, THE VALET ASKED TO TURN…
Read full complaint
CAR LOCKED ITSELF WITH DRIVER AND PASSENGERS INSIDE CAR. NO ONE COULD OPEN DOORS FROM INSIDE. THE MANUAL UNLOCK WOULD NOT UNLOCK DOORS. DRIVER WAS ABLE TO UNLOCK HIS DOOR BY OPENING WINDOW AND USING THE OUTSIDE DOOR HANDLES. *TR THIS INCIDENT HAS HAPPENED THREE TIMES. ON ANOTHER INCIDENT WHILE PARKING, THE VALET ASKED TO TURN CAR OFF LEAVE CAR KEYS INSIDE CAR. AS DRIVER LEFT THE CAR AND CLOSED THE DOOR, THE CAR LOCKED ITSELF (WITH THE KEYS INSIDE). THIS HAS OCCURRED TWICE IN THE PAST COUPLE OF MONTHS.
DRIVING BACK HOME FROM LAS VEGAS, NV ABOUT 150 MILES AWAY (UTAH) THE A/T LIGHT CAME ON. LOOKED IT UP ONLINE IT STATED AUTO/TRANSMISSION OIL TEMP IS HIGH.DECIDED TO PULL OVER AND LET IT COOL DOWN AT THE NEAREST GAS STATION. DECIDED IT WAS OK SINCE THE TEMP IN UTAH WENT DOWN THIS WAS AROUND 2 PM. ABOUT 10 MIN LATER WHEN WE GOT BA…
Read full complaint
DRIVING BACK HOME FROM LAS VEGAS, NV ABOUT 150 MILES AWAY (UTAH) THE A/T LIGHT CAME ON. LOOKED IT UP ONLINE IT STATED AUTO/TRANSMISSION OIL TEMP IS HIGH.DECIDED TO PULL OVER AND LET IT COOL DOWN AT THE NEAREST GAS STATION. DECIDED IT WAS OK SINCE THE TEMP IN UTAH WENT DOWN THIS WAS AROUND 2 PM. ABOUT 10 MIN LATER WHEN WE GOT BACK ONTO HIGHWAY THE A/T LIGHT CAME ON AGAIN. THEN THE CAR STARTED TO SMOKE FROM THE ENGINE BAY. WE PULLED OVER TOOK A LOOK AT IT REALIZED NO PUNCTURE TO THE LINES AND FIGURED THE PRESSURE BUILD UP FROM TRANNY SPAT OUT FROM WHERE YOU USUALLY POUR FLUIDS IN. WE TRIED GETTING OFF HWY FOR SAFETY AND ENDED UP MIDDLE ON NO WHERE. THEN WE WAITED TIL 5 PM AND AS THE WEATHER COOLED DOWN WE STARTED THE DRIVE AGAIN. THE ENGINE WAS FINE THE TRANSMISSION WOULDN'T LET ME PUSH IT PASS 3 1/2 RPM SO WE DROVE ABOUT 50-70 MPH. WE REACHED COLORADO THEN SPENT THE NIGHT. THE NEXT DAY IT STARTED TO SNOW, THE TRANSMISSION DECIDED TO STOP RESPONDING IT WILL GO INTO GEARS BUT IT WILL STALL AND GO BUT IT WOULDN'T LET ME GO PAST 2 RPM. CHECK ENGINE LIGHT CAME ON THEN WE DECIDED TO TAKE THE CAR TO AUTOZONE. THE O2 TEST STATED: LOW TRANNY OIL, TORQUE CONTROL SOLENOID SENSOR, AND ELECTRICAL SENSOR. THEN WE HAD THE CAR TOW TO NEARBY TRANSMISSION SHOP THEY RAN SOME DIAGNOSTICS AND SAID THE GEARS ARE SLIPPING AND THE WHOLE TRANSMISSION NEEDS TO BE REBUILT. TOTAL COST IN REBUILT 4100.00 OUT THE DOOR. CAR IN ON 3/4/13 CAR WAS DONE ON 3/19/13. *TR
TL* THE CONTACT OWNS A 2002 ACURA MDX. THE CONTACT WAS DRIVING 50 MPH WHEN THE SRS AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A PERSONAL MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE ENTIRE SENSORY BOARD NEEDED TO BE REPLACED. THE CONTACT THEN TOOK THE VEHICLE TO A DEALER WHERE SHE WAS INFORMED OF…
Read full complaint
TL* THE CONTACT OWNS A 2002 ACURA MDX. THE CONTACT WAS DRIVING 50 MPH WHEN THE SRS AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A PERSONAL MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE ENTIRE SENSORY BOARD NEEDED TO BE REPLACED. THE CONTACT THEN TOOK THE VEHICLE TO A DEALER WHERE SHE WAS INFORMED OF A MANUFACTURER'S RECALL BUT NO ASSISTANCE WAS OFFERED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 101,000.
1.) THE AT SHIFT GEAR SLIDES OUT OF PARK EVEN WHEN VEHICLE IS TURNED OFF. VERY DANGEROUS FOR CHILDREN SHIFTING GEARS OUT OF PARK WHILE KEY IS OUT OF THE IGNITION! PER CONVERSATION WITH CONSUMER, THE DEALER HAS IDENTIFIED THAT THE SHIFT-INTERLOCK SOLENOID ASSEMBLY WAS DAMAGED AND REPLACED UNDER WARRANTY TO CUSTOMER'S SATISFACTI…
Read full complaint
1.) THE AT SHIFT GEAR SLIDES OUT OF PARK EVEN WHEN VEHICLE IS TURNED OFF. VERY DANGEROUS FOR CHILDREN SHIFTING GEARS OUT OF PARK WHILE KEY IS OUT OF THE IGNITION! PER CONVERSATION WITH CONSUMER, THE DEALER HAS IDENTIFIED THAT THE SHIFT-INTERLOCK SOLENOID ASSEMBLY WAS DAMAGED AND REPLACED UNDER WARRANTY TO CUSTOMER'S SATISFACTION. ALSO LEARNED THAT 4-YR OLD BOY INSIDE VEHICLE POTENTIALLY DAMAGED GEAR SHIFT RESULTING IN FREE MOVEMENT FROM PARK TO OTHER GEAR(S). *MJJ 2.) ATF TEMP SENSOR REMAINS ON IN DASHBOARD EVEN WHILE TRANS IS COOL. ELECTRICAL PROBLEM CODE (DTC) PO710. 3.) THE D5 GEAR INDICATOR LIGHT REMAINS ON AND FLASHING WHILE DRIVING. VEHICLE WAS TOWED TO ACURA DEALER IN LATHAM,NY FOR ELECTRICAL REPAIRS. *JB
Official recalls
420V027000 · Air Bags:frontal:driver Side:inflator Module
Jan 17, 2020
Honda (American Honda Motor Co.) is recalling certain 2001-2002 Acura 3.2CL, 2000-2003 Acura 3.5RL, 2000-2001 Acura 3.2TL, Honda CR-V and Honda Odyssey, 2001-2002 Acura MDX and 2000 Accord Coupe, Accord Sedan, Civic Coupe, and Civic Sedan vehicles. These vehicles may have received a replacement driver frontal air bag module as part of a vehicle repair. Due to a manufacturing issue, the replacement NADI inflator may absorb moisture, causing the inflator to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the air bags in the vehicles, replacing the driver frontal air bag inflator with an inflator of a different design, as necessary, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138.
05V385000 · Suspension:front:springs:coil Springs
Sep 1, 2005
ON CERTAIN SPORT UTILITY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA. IN AREAS WHERE LARGE QUANTITIES OF ROAD SALT ARE USED, THE FRONT SUSPENSION COIL SPRINGS HAVE INSUFFICIENT CORROSION PROTECTION, AND MAY BE SUSCEPTIBLE TO CORROSION.
Consequence & remedy
Consequence: EXCESSIVE CORROSION CAN CAUSE SPRING FAILURE AND A BROKEN SPRING COULD PUNCTURE A FRONT TIRE, WHICH INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH FRONT SPRINGS WITH IMPROVED SPRINGS. THE RECALL BEGAN ON OCTOBER 11, 2005. OWNERS MAY CONTACT ACURA AT 800-382-2238.
04V176000 · Power Train:automatic Transmission
Apr 15, 2004
ON SOME MINI VANS, SPORT UTILITY AND PASSENGER VEHICLES, CERTAIN OPERATING CONDITIONS CAN RESULT IN HEAT BUILD-UP BETWEEN THE COUNTERSHAFT AND SECONDARY SHAFT SECOND GEARS IN THE AUTOMATIC TRANSMISSION, EVENTUALLY LEADING TO GEAR TOOTH CHIPPING OR GEAR BREAKAGE.
Consequence & remedy
Consequence: GEAR FAILURE COULD RESULT IN TRANSMISSION LOCKUP, WHICH COULD RESULT IN A CRASH.
Remedy: ON VEHICLES WITH 15,000 MILES OR LESS, THE DEALER WILL UPDATE THE TRANSMISSION WITH A SIMPLE REVISION TO THE OIL COOLER RETURN LINE TO INCREASE LUBRICATION TO THE SECOND GEAR. ON VEHICLES WITH MORE THAN 15,000 MILES, THE DEALER WILL INSPECT THE TRANSMISSION TO IDENTIFY GEARS THAT HAVE ALREADY EXPERIENCED DISCOLORATION DUE TO OVERHEATING. IF DISCOLORATION EXISTS, THE TRANSMISSION WILL BE REPLACED IF DISCOLORATION IS NOT PRESENT, THE DEALER WILL PERFORM THE REVISION TO THE OIL COOLER RETURN LINE. THE RECALL BEGAN ON APRIL 21, 2004, FOR PILOT, ODYSSEY, AND MDX OWNERS. OWNERS OF THE ACCORD VEHICLES WILL START RECEIVING LETTERS ON JUNE 28, 2004, AND ON JUNE 29, 2004, FOR OWNERS OF THE TL AND CL VEHICLES. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
02V226000 · Engine And Engine Cooling:engine
Aug 28, 2002
ON CERTAIN MINIVANS, SEDANS, COUPES, AND SPORT UTILITY VEHICLES EQUIPPED WITH V6 ENGINES, A TIMING BELT TENSIONER PULLEY ON THE WATER PUMP IS MISALIGNED AND COULD CAUSE THE TIMING BELT TO CONTACT A BOLT ON THE CYLINDER HEAD. EVENTUALLY THE BELT COULD BE DAMAGED AND FAIL.
Consequence & remedy
Consequence: IF THE TIMING BELT BREAKS, THE ENGINE WILL STALL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE WATER PUMP AND IF IT IS ONE OF THE DEFECTIVE PUMPS, THE WATER PUMP AND TIMING BELT WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 30, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE05040 · Front Coil Spring Breakage
Opened Jul 14, 2005 · Closed Sep 14, 2005
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs; Tires
IN AN AUGUST 29, 2005 LETTER, HONDA NOTIFIED NHTSA THAT IT HAD IDENTIFIED A DEFECT IN THE FRONT COIL SPRINGS OF CERTAIN MODEL YEAR 2001 AND EARLY-2002 ACURA MDX SPORT UTILITY VEHICLES.ACCORDING TO HONDA, SOME FRONT SUSPENSION COIL SPRINGS HAVE INSUFFICIENT CORROSION PROTECTION AND, IN AREAS WHERE ROAD SALTS ARE USED, MAY BE SUSCEPTIBLE TO CORROSION.RUBBER SLEEVES APPLIED NEAR THE TOP AND BOTTOM OF SOME SPRINGS TO ELIMINATE NOISE CAN TRAP SALT WATER, INCREASING THE POTENTIAL FOR EXCESSIVE CORROSION.OVER TIME, EXCESSIVE CORROSION CAN CAUSE SPRING FAILURE.IN SOME CASES, A BROKEN SPRING COULD PUNCTURE A FRONT TIRE, WHICH INCREASES THE RISK OF A CRASH.EVIDENCE OF TIRE DAMAGE WAS IDENTIFIED IN AT LEAST 4 (29%) OF THE SPRING FRACTURE REPORTS AND 13 (21%) OF THE WARRANTY CLAIMS.ONE REPORT ALSO INDICATED THAT A FRACTURED SPRING DAMAGED A BRAKE LINE FAILURE, RESULTING IN EXTENDED STOPPING DISTANCE. TO CORRECT THE CONDITION, HONDA IS RECALLING APPROXIMATELY 22,861 MDX VEHICLES SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA WHERE LARGE QUANTITIES OF ROAD SALT ARE USED (HONDA RECALL P92, NHTSA RECALL 05V-385).THERE WERE NO COMPLAINTS OR WARRANTY CLAIMS INVOLVING VEHICLES FROM OUTSIDE THE RECALL REGION.DEALERS WILL REPLACE BOTH FRONT SUSPENSION COIL SPRINGS WITH IMPROVED SPRINGS.
Additional source detail variants (2)
Suspension:front:springs:coil Springs
IN AN AUGUST 29, 2005 LETTER, HONDA NOTIFIED NHTSA THAT IT HAD IDENTIFIED A DEFECT IN THE FRONT COIL SPRINGS OF CERTAIN MODEL YEAR 2001 AND EARLY-2002 ACURA MDX SPORT UTILITY VEHICLES.ACCORDING TO HONDA, SOME FRONT SUSPENSION COIL SPRINGS HAVE INSUFFICIENT CORROSION PROTECTION AND, IN AREAS WHERE ROAD SALTS ARE USED, MAY BE SUSCEPTIBLE TO CORROSION.RUBBER SLEEVES APPLIED NEAR THE TOP AND BOTTOM OF SOME SPRINGS TO ELIMINATE NOISE CAN TRAP SALT WATER, INCREASING THE POTENTIAL FOR EXCESSIVE CORROSION.OVER TIME, EXCESSIVE CORROSION CAN CAUSE SPRING FAILURE.IN SOME CASES, A BROKEN SPRING COULD PUNCTURE A FRONT TIRE, WHICH INCREASES THE RISK OF A CRASH.EVIDENCE OF TIRE DAMAGE WAS IDENTIFIED IN AT LEAST 4 (29%) OF THE SPRING FRACTURE REPORTS AND 13 (21%) OF THE WARRANTY CLAIMS.ONE REPORT ALSO INDICATED THAT A FRACTURED SPRING DAMAGED A BRAKE LINE FAILURE, RESULTING IN EXTENDED STOPPING DISTANCE. TO CORRECT THE CONDITION, HONDA IS RECALLING APPROXIMATELY 22,861 MDX VEHICLES SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA WHERE LARGE QUANTITIES OF ROAD SALT ARE USED (HONDA RECALL P92, NHTSA RECALL 05V-385).THERE WERE NO COMPLAINTS OR WARRANTY CLAIMS INVOLVING VEHICLES FROM OUTSIDE THE RECALL REGION.DEALERS WILL REPLACE BOTH FRONT SUSPENSION COIL SPRINGS WITH IMPROVED SPRINGS.
Tires
IN AN AUGUST 29, 2005 LETTER, HONDA NOTIFIED NHTSA THAT IT HAD IDENTIFIED A DEFECT IN THE FRONT COIL SPRINGS OF CERTAIN MODEL YEAR 2001 AND EARLY-2002 ACURA MDX SPORT UTILITY VEHICLES.ACCORDING TO HONDA, SOME FRONT SUSPENSION COIL SPRINGS HAVE INSUFFICIENT CORROSION PROTECTION AND, IN AREAS WHERE ROAD SALTS ARE USED, MAY BE SUSCEPTIBLE TO CORROSION.RUBBER SLEEVES APPLIED NEAR THE TOP AND BOTTOM OF SOME SPRINGS TO ELIMINATE NOISE CAN TRAP SALT WATER, INCREASING THE POTENTIAL FOR EXCESSIVE CORROSION.OVER TIME, EXCESSIVE CORROSION CAN CAUSE SPRING FAILURE.IN SOME CASES, A BROKEN SPRING COULD PUNCTURE A FRONT TIRE, WHICH INCREASES THE RISK OF A CRASH.EVIDENCE OF TIRE DAMAGE WAS IDENTIFIED IN AT LEAST 4 (29%) OF THE SPRING FRACTURE REPORTS AND 13 (21%) OF THE WARRANTY CLAIMS.ONE REPORT ALSO INDICATED THAT A FRACTURED SPRING DAMAGED A BRAKE LINE FAILURE, RESULTING IN EXTENDED STOPPING DISTANCE. TO CORRECT THE CONDITION, HONDA IS RECALLING APPROXIMATELY 22,861 MDX VEHICLES SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA WHERE LARGE QUANTITIES OF ROAD SALT ARE USED (HONDA RECALL P92, NHTSA RECALL 05V-385).THERE WERE NO COMPLAINTS OR WARRANTY CLAIMS INVOLVING VEHICLES FROM OUTSIDE THE RECALL REGION.DEALERS WILL REPLACE BOTH FRONT SUSPENSION COIL SPRINGS WITH IMPROVED SPRINGS.